美國力沃LEO]進口杠桿浮球式是利用浮力原理和杠桿原理，通過液位的變化使浮球上升或下降，浮球驅動著杠桿使得閥瓣離開或接觸閥座達到開啟排水和關閉阻汽的作用。采用自動排空氣閥，能自動排除不凝結氣體，非常靈敏，工作質量高，使用壽命長。連續排水，有水即排，zui小過冷度為┃0℃。杠桿浮球式疏水閥采用兩種結構方式┃A：單閥座-杠桿浮球;┃B：雙平衡閥座-杠桿浮球。

單閥座：需要克服介質壓力對閥座的作用，閥座的孔徑不能很大，適用于小型設備、伴熱管線，蒸汽主管等排水小的場合。閥座孔設計在凝結水水位以下，自然形成水封，水、汽自然分離，達到無蒸汽泄漏，即便沒有凝結水采用球型密封的杠桿使得閥瓣緊貼閥座，達到無新鮮蒸汽的泄漏。不受凝結水量波動和溫度的影響。

雙平衡閥座：該閥利用雙閥孔設計，介質的壓力對兩個閥座作用相等，方向相反，介質壓力對閥座作用相抵消，閥芯在開閥時壓力相對減少，從而獲得超大排量。工作時浮球隨閥腔內液體位的變化而上下浮動，帶動杠桿打開或關閉閥座。由于閥座孔在凝結水水位以下，形成水封，水、汽自然分離，達到無蒸汽泄漏。不受壓力、溫度、冷凝水流量波動的影響。

┃Lever-ball┃float┃trap

The┃lever-ball┃float┃type┃trap┃employs┃the┃buoyancy┃and┃leverage┃principles:┃to┃make┃the┃ball┃float┃ascend┃or┃descend┃by┃the┃change┃in┃the┃liquid┃level┃and┃then┃the┃ball┃float┃drives┃the┃lever┃to┃make┃the┃valve┃disc┃depart┃from┃or┃touch┃the┃valve┃seat┃to┃realize┃drainage┃and┃close┃the┃block┃vapor.┃The┃product┃adopts┃the┃automatic┃air┃exhaust┃to┃automatically┃eliminate┃non-condensing┃air.┃It┃is┃very┃precise┃with┃high┃operating┃quality┃and┃long┃service┃life.┃It┃can┃discharge┃whenever┃there┃is┃any┃water,┃and┃its┃minimum┃subcooled┃temperature┃is┃0℃.┃The┃lever-┃ball┃float┃trap┃adopts┃two┃kinds┃of┃structure┃modes:┃A:┃Single┃valve┃seat-lever┃ball┃float;┃B:┃double┃balanced┃valve┃seat-lever┃ball┃float.┃

Single┃valve┃seat:┃it┃needs┃to┃overcome┃the┃operation┃on┃the┃valve┃seat┃by┃the┃medium┃pressure;┃the┃hole┃caliber┃of┃the┃valve┃seat┃cannot┃be┃too┃large┃and┃is┃applicable┃to┃such┃low┃displacement┃condition┃as┃mini-equipment,┃steam┃tracing┃pipeline┃and┃steam┃main┃pipe.┃The┃hole┃of┃the┃valve┃seat┃is┃designed┃beneath┃the┃water┃level┃of┃the┃condensate┃water┃to┃form┃water┃sealing┃to┃keep┃water┃apart┃from┃vapor,┃so┃as┃to┃prevent┃the┃leakage┃of┃the┃vapor.┃Though┃there┃is┃no┃condensate┃water┃that┃uses┃ball-type┃sealed┃lever┃to┃make┃the┃valve┃clack┃tightly┃adhesion┃to┃the┃valve┃seat,┃it┃can┃prevent┃the┃fresh┃vapor┃from┃leakage.┃Further,┃the┃product┃is┃free┃of┃the┃affect┃of┃the┃fluctuation┃of┃the┃condensate┃water’s┃quantity┃and┃temperature.

The┃double┃balanced┃valve┃seat:┃this┃valve┃is┃designed┃to┃have┃two┃valve┃openings.┃The┃pressure┃of┃the┃medium┃act┃against┃the┃two┃valve┃seats┃equally┃in┃reverse┃direction,┃so┃the┃pressure┃on┃the┃valve┃seat┃is┃offset,┃the┃valve┃core┃assumes┃relatively┃low┃pressure┃when┃the┃valve┃is┃open,┃in┃this┃way┃the┃overlarge┃displacement┃is┃obtained.┃During┃the┃operating┃process,┃the┃ball┃float┃floats┃with┃the┃change┃in┃liquid┃level┃of┃the┃valve┃cavity┃to┃make┃the┃lever┃open┃or┃close┃the┃valve┃seat.┃The┃hole┃of┃the┃valve┃seat┃is┃designed┃beneath┃the┃water┃level┃of┃the┃condensate┃water┃to┃form┃water┃sealing┃to┃keep┃water┃apart┃from┃vapor,┃so┃as┃to┃prevent┃the┃leakage┃of┃the┃vapor.┃Further,┃the┃product┃is┃free┃of┃the┃affect┃caused┃by┃the┃fluctuation┃of┃pressure,┃temperature┃and┃condensate’s┃flow